Power & Operations

Chatterjee

The Trump administration on November 5 removed Neil Chatterjee from the chairmanship of the Federal Energy Regulatory Commission, replacing him with fellow Republican James Danly, who was confirmed to a seat on the commission in March.

Chatterjee joined FERC in 2017, serving as chairman from August to December 2017. He returned to the leadership role in October 2018, following the departure of Kevin McIntyre. In a tweet, Chatterjee said that he intends to complete his term, which expires in June 2021.

Watts Bar. Photo: TVA

One week after issuing a six-figure civil penalty to the Tennessee Valley Authority for violating Nuclear Regulatory Commission rules involving employee protection, the NRC has proposed penalties totaling more than $900,000 on TVA for a 2015 incident at the utility’s two-unit Watts Bar nuclear plant, located near Spring City, Tenn.

The NRC also has issued violations to two managers and a reactor operator for their roles in the incident.

The enforcement actions are the result of an NRC investigation—initiated in August 2016 and completed in May of last year—into events that occurred during and after the startup of Watts Bar-1 following a maintenance outage in November 2015.

The Nuclear Regulatory Commission is requesting public input on preliminary language for a proposed rule that would set out a risk-informed, technology-inclusive framework for the licensing and regulation of advanced nuclear reactors, according to a notice published in the November 6 Federal Register.

The Nuclear Energy Innovation and Modernization Act, or NEIMA, signed into law in January 2019, tasked the agency with developing a regulatory infrastructure for the development and commercialization of advanced reactors.

The Nuclear Regulatory Commission on October 29 imposed a civil penalty of $606,942 on the Tennessee Valley Authority for violating the agency’s rules involving employee protection, after proposing the fine and issuing four related violation notices in August.

Following investigations completed in October 2019 and January 2020, the NRC concluded that two former TVA employees had been subjected to reprisals for raising concerns regarding a chilled work environment.

In a November 4 Federal Register notice, the NRC notes that TVA responded to the proposed fine on September 23, denying all four violations and arguing (unsuccessfully) that “if the NRC continues to believe that the violations occurred, then at a minimum the NRC should reduce the severity level of the alleged violations and commensurately reduce the civil penalty.”

The U.K. National Nuclear Laboratory’s Colin Fairbairn (left) and Ben Smith (in pre-COVID days) work on the Box Encapsulation Plant (BEP) robots project at the NNL’s facility in Workington, Cumbria, U.K. Photos: UKNNL

Though robotics solutions have been used across many industries, for many purposes, Sellafield Ltd has begun to bring robotics to the U.K. nuclear industry to conduct tasks in extreme environments. The Sellafield site, in Cumbria, United Kingdom, contains historic waste storage silos and storage ponds, some of which started operations in the 1950s and contain some of the most hazardous intermediate--level waste in the United Kingdom. There is a pressing need to decommission these aging facilities as soon as possible, as some of them pose significant radiation risk.

Although a much-discussed October 12 story from Bloomberg headlined “Exelon Weighs Shedding Nuclear Plants, Other Non-Utility Assets” went unconfirmed, a new report from Greentech Media says that confirmation has now taken place.

Artist’s rendering of a Holtec SMR-160 plant. Image: Holtec International.

Holtec International announced yesterday a drive to secure Nuclear Regulatory Commission design certification of the company’s SMR-160 small modular reactor on an accelerated schedule.

According to the announcement, Holtec met with NRC officials and staff on September 30 to present a licensing roadmap that charts what the company referred to as a “seamless progression from [10 CFR Part 50] to [10 CFR Part 52] and a licensing topical report submittal schedule to support an accelerated availability plan for our global customers.”

The first planned submittal, scheduled to occur within the next few weeks, is a topical report covering the SMR-160’s essential safety features: the Passive Core Cooling System (PCCS) and Passive Containment Heat Removal System (PCHR). These systems, Holtec said, “undergird the SMR’s guaranteed safety under the various operational occurrences and hypothetical accidents that may afflict the plant.”

The submittal also aims to demonstrate that the PCCS and PCHR comply with the NRC’s General Design Criteria (Part 50, Appendix A), “an important enabler to expedite licensing efforts,” according to Holtec.

The Belarusian nuclear power plant. Photo: Rosatom

Belarus on November 3 became the latest nation to begin generating electricity with nuclear energy when Unit 1 of the Belarusian nuclear plant was connected to the country’s power grid.

The Belarusian construction project, located in the Grodno region of Belarus, features twin 1,109-MWe pressurized water reactors, supplied by Rosatom, Russia’s state-owned nuclear energy corporation. The units are VVER-1200 Generation III+ designs, model AES 2006. Just last week, a VVER-1200 was connected to the Russian grid at the Leningrad plant.

The start-up program for Unit 1 began on August 7, when the first fuel assembly with fresh nuclear fuel was loaded into the reactor, according to a Rosatom press release. The reactor achieved first criticality on October 11.

Once fully completed, the plant is expected to supply approximately 18 billion kWh of low-carbon electricity to the Belarus national grid every year, Rosatom said.

Artist’s rendering of the Sizewell site, with Sizewell C at right. Image: EDF Energy

A BBC News story from late last week states that the U.K. government “is close to giving the green light” to EDF Energy’s proposed Sizewell C nuclear new build project in Suffolk, adding that details surrounding the project’s financing “are still being hammered out.”

The Sizewell C station, consisting of twin European pressurized reactors (EPRs), would be built next to Sizewell B, a 1,198-MWe pressurized water reactor that began operation in 1995. (The Sizewell site also houses Sizewell A, a 290-MWe Magnox gas-cooled reactor, but that unit was permanently shuttered in 2006.) Sizewell C would be a near copy of the two-unit Hinkley Point C station, currently under construction in Somerset.

Chuck Jones, former FirstEnergy CEO

Akron, Ohio-based FirstEnergy Corporation—former parent of Energy Harbor, the owner of Ohio’s Davis-Besse and Perry nuclear plants—announced on October 29 that it has fired its chief executive officer, Charles “Chuck” Jones, as well as its senior vice president of product development, marketing, and branding and its senior vice president of external affairs.

The actions, according to FirstEnergy, were prompted by an internal company review undertaken in response to the scandal surrounding H.B. 6—the now infamous legislation signed into law last year by Ohio Gov. Mike DeWine that includes subsidies for Davis-Besse and Perry and that is at the heart of an alleged multi-million dollar racketeering and corruption scheme aimed at guaranteeing its passage.

In the announcement, FirstEnergy said only that its review “determined that these executives violated certain FirstEnergy policies and its code of conduct.” Replacing Jones is Steven E. Strah, who had been the firm’s president.

A nuclear advocacy group is asking the Federal Energy Regulatory Commission to review the approval by California regulators of the decision by Pacific Gas and Electric in 2016 to prematurely retire its Diablo Canyon plant—the Golden State’s only remaining operating nuclear power facility—in 2025.

On October 26, the nonprofit organization Californians for Green Nuclear Power Inc. (CGNP) filed a 32-page complaint with FERC in the matter, listing as respondents the North American Electric Reliability Corporation (NERC), Western Electricity Coordinating Council (WECC), California Independent System Operator (CAISO), California Public Utilities Commission (CPUC), California State Water Resources Control Board (CSWRCB), and California State Lands Commission (CSLC).

The Zephyr system uses probes for steam generator inspections. Photos: APS

The Palo Verde Nuclear Generating Station, a three-unit pressurized water reactor plant operated by Arizona Public Service Company, has started using an inspection technology relatively new to the nuclear industry. The technology, called smart pigs (an acronym for “piping inline gauges”), has previously been employed by oil and gas companies for inspecting and cleaning underground pipes. After testing and analyzing smart pig products from several companies, Palo Verde’s underground piping consultant, Dan Wittas, selected a smart pig suitable for navigating the tight-radius bends in the plant’s spray pond piping. The spray pond system consists of piping, a pump, and a reservoir where hot water (from the Palo Verde plant) is cooled before reuse by pumping it through spray nozzles into the cooler air. Smart pigs work by using the water’s flow through the piping to move an inspection tool within the pipe itself. The technology replaces the previous method of pipe inspection, in which various relatively small sections of piping were unearthed and directly inspected, and were considered to be representative examples of the overall piping condition. In contrast, the smart pigs obtain corrosion levels for the length of piping traveled through and allow a corrosion baseline to be established.

From left: Secretary of Defense Mark Esper and Secretary of State Mike Pompeo participate in the U.S.-India 2+2 Ministerial Dialogue plenary session with Indian Defense Minister Rajnath Singh and Indian External Affairs Minister Subrahmanyam Jaishankar in New Delhi, India, on October 27, 2020. Photo: State Department/Ron Przysucha

In New Delhi earlier this week, U.S. Secretary of State Mike Pompeo and Secretary of Defense Mark Esper joined their Indian counterparts, Minister of External Affairs Subrahmanyam Jaishankar and Minister of Defense Rajnath Singh, for the third U.S.-India 2+2 Ministerial Dialogue—a yearly confab focused on strengthening the strategic relationship between the two nations. (In February of this year, the White House elevated that relationship to Comprehensive Global Strategic Partnership status.)

The first 2+2 dialogue took place in New Delhi in September 2018, with a second held in Washington, D.C., in 2019. Washington is scheduled to host the fourth such meeting next year.

Watts Bar Unit 2. Photo: TVA

The Nuclear Regulatory Commission has approved a request from the Tennessee Valley Authority to increase the generating capacity of Unit 2 at the Watts Bar nuclear power plant by 1.4 percent, according to an October 27 press release from the agency. TVA submitted its application for the power uprate on October 10, 2019, and the NRC issued the required license amendment on October 21.

The power uprate, which TVA intends to implement by mid-December, will increase Unit 2’s generating capacity from approximately 1,223 MWe to 1,240 MWe.

“The NRC staff determined that TVA could safely increase the reactor’s output, primarily through more accurate means of measuring feedwater flow,” the press release stated, adding, “NRC staff also reviewed the TVA evaluations demonstrating that the plant’s design can safely handle the increased power level.”

Rosenergoatom, the electric power division of Russia’s state-owned nuclear power corporation Rosatom, announced on October 23 that Leningrad II-2 has been connected to the grid. The unit is one of two Generation III+ VVER-1200 pressurized water reactors at the Leningrad nuclear plant.

The reactor will replace Leningrad I-2, a 925-MWe RBMK-1000 light-water–cooled graphite-moderated reactor that will permanently cease operation at the end of 2020 after 45 years of service. Fuel loading at Leningrad II-2 began in July, and initial criticality was achieved in August. Following the trial operation, the unit will be shut down for an additional equipment inspection by a state commission before being put into commercial operation early next year, according to Rosenergoatom.

Rising

Agneta Rising, outgoing director general of the World Nuclear Association, wrote in an October 27 World Nuclear News article that nuclear power is an essential part of the climate change solution, even if it is not part of the conversation in the European Union. “In many ways, the future of nuclear energy is much brighter than it has been for many years. We are evermore recognized and valued for the unique services that nuclear energy offers humanity, and I am immensely proud to have served and led our industry through these exciting times," said Rising in a farewell message that recapped her time as WNA director general.

Advanced reactor developers see potential markets for reactors in a range of sizes that offer clean, reliable, flexible, and cost-competitive power. Many have reached agreements with suppliers, utilities, and others to support the demonstration and possible deployment of their designs. Nuclear News is following these activities. Read on for updates and check back with Newswire often for more on the Advanced Reactor Marketplace.

Canada has invested Can$20 million in Terrestrial Energy’s 195-MW Integral Molten Salt Reactor through the Ministry of Innovation, Science and Industry, the company announced on October 15. In accepting the investment, Terrestrial Energy, which is based in Oakville, Ontario, has committed to creating and maintaining 186 jobs and creating 52 co-op positions nationally. In addition, Terrestrial Energy is spending at least $91.5 million on research and development. According to the company, the funds will assist with the completion of a key pre-licensing milestone with the Canadian Nuclear Safety Commission.

Two days earlier, Terrestrial Energy USA and Centrus Energy announced that they had signed a memorandum of understanding to evaluate the logistical, regulatory, and transportation requirements to establish a fuel supply for Integral Molten Salt Reactor power plants, which would use standard-assay low-enriched uranium at an enrichment level less than 5 percent.

In testimony filed last week with the Georgia Public Service Commission, Georgia Power and Southern Nuclear acknowledge that the “aggressive” target dates set in July for some of the Vogtle construction project’s upcoming milestones have had to be pushed back by a few months. At the same time, however, the companies continue to express confidence in being able to meet the regulatory-approved commercial start dates for the new reactors—November 2021 for Unit 3 and November 2022 for Unit 4.

The testimony was filed in support of Georgia Power’s Twenty-third Semi-annual Vogtle Construction Monitoring Report, released in August, which covers the period from January 1 to June 30, 2020.

Bulgaria’s Kozloduy nuclear plant. Photo: Wikimedia Commons/Gogo89873

The United States in the past few weeks has signed civil nuclear agreements with Romania and Poland, and now a third European nation can be added to the list: Bulgaria.

Unit 5 at China National Nuclear Corporation’s (CNNC) Fuqing nuclear power plant has achieved initial criticality, becoming the very first Hualong One reactor to reach that milestone, the company announced on October 22. If all goes according to schedule, the unit will enter commercial operation later this year.

Fuel loading for Unit 5 began on September 4, following the issuance of the reactor’s operating license by China’s Ministry of Ecology and Environment. The loading of 177 sets of fuel assemblies was completed on September 10.

Also known as the HPR1000, the Hualong One is a Chinese-designed, 1,000-MWe Generation III pressurized water reactor. Fuqing-5’s twin HPR1000, Fuqing-6, is scheduled to start contributing power to the grid next year.

Located in China’s Fujian Province, Fuqing also houses four 1,000-MWe CPR-1000 PWRs, with commercial start dates of November 2014, October 2015, October 2016, and September 2017.